Owner: Department of Defense, Eglin Air Force Base
Project Location: Eglin AFB Florida
Prime Contractor: SheltonDean, Inc.
Contract: #FA2823-05-C-0046
Contract Value: $285,000
Percentage of Self-Performed Work: 85%

Self-Performed Work: All management and supervision, mechanical, plumbing and electrical.

Description of Contract: Installation of 65 ton DX 100% outside air unit with heat recovery wheel and hot water boilers and related building automation system.
 

Owner: Department of Defense, Eglin Air Force Base
Project Location: Site A-15, Eglin Air Force Base, Florida
Prime Contractor: SheltonDean, Inc.
Contract: #FA2823-06-C-0075
Contract Value: $492,000
Percentage of Self-Performed Work: 95%

Self-Performed Work: All supervision and management, concrete, electrical, mechanical and specialties.

Description of Contract: Building of elevated transformer platforms and running new primary and secondary power to four facilities.
 

Owner: Department of Defense, Eglin Air Force Base
Project Location: Site A-17, Eglin Air Force Base, Florida
Prime Contractor: SheltonDean, Inc.
Contract: #FA2823-06-C-0071
Contract Value: $887,000
Percentage of Self-Performed Work: 95%

Self-Performed Work: All supervision and management, concrete, mechanical, electrical and specialties.

Description of Contract: Building of two Elevated Concrete Transformer Platforms, Installation of primary underground power and secondary power, Repair of radar facility and paving.
 

Owner: Department of Defense, Eglin AFB Florida
Project Location: Building 12722, Eglin AFB, Florida
Prime Contractor: SheltonDean, Inc.
Contract: #FA2823-06-0064
Contract Value: $324,000
Percentage of Self-Performed Work: 90%

Self-Performed Work: All supervision and management, electrical and mechanical.

Description of Contract: Installation of two 100 air-cooled Trane Chillers with associated pumps and re-piping to the chill water system.
 

Owner: Department of Defense, Eglin Air Force Base
Project Location: Eglin AFB Florida
Prime Contractor: SheltonDean, Inc.
Contract: #FA2823-05-C-0034
Contract Value: $238,000
Percentage of Self-Performed Work: 85%

Self-Performed Work: All management and supervision, mechanical, plumbing and electrical.

Description of Contract: Installation of DX cooling system with heat recovery wheel and associated pumps and piping.
 

Owner: Department of Defense, Eglin Air Force Base
Project Location: Eglin AFB Florida
Prime Contractor: SheltonDean, Inc.
Contract: #FA2823-05-C-0047
Contract Value: $732,262
Percentage of Self-Performed Work: 85%

Self-Performed Work: All management and supervision, demolition, sitework, concrete, masonry, roofing, hollow metal, mechanical, plumbing and electrical.

Description of Contract: Provide for the installation of a HVAC system in Eglin Air force Base-Building 810. This project included demolition of existing windows, retrofit of the existing structure with new CMU, concrete beams and hollow metal windows, construction of new CMU mechanical room, installation of a new HVAC system and tie-in to existing utility system.
 

Owner: Department of Defense, Eglin Air Force Base
Project Location: Building 106, Eglin AFB, Florida
Prime Contractor: SheltonDean, Inc.
Contract: # FA-2823-07-R-0034
Contract Value: $62,194
Percentage of Self-Performed Work: 90%

Self-Performed Work: All management and supervision, demolition, concrete, mechanical, and electrical.

Description of Contract: Construction of jack stand testers
 

Owner: Department of Defense, Eglin Air Force Base
Project Location: Site A-17, Eglin Air Force Base, Florida
Prime Contractor: SheltonDean, Inc.
Contract: #FA2823-06-C-0071
Contract Value: $887,000
Percentage of Self-Performed Work: 95%

Self-Performed Work: All supervision and management, concrete, mechanical, electrical and specialties.

Description of Contract: Building of two Elevated Concrete Transformer Platforms, Installation of primary underground power and secondary power, Repair of radar facility and paving.
 

Owner: Department of Defense, Hurlburt AFB
Project Location: Building 90333 Hurlburt AFB, Florida
Prime Contractor: SheltonDean, Inc.
Contract: FA-4417-07-M-K002
Contract Value: $23,637
Percentage of Self-Performed Work: 100%

Self-Performed Work: All supervision and management, electrical and mechanical.

Description of Contract: Replace condensate drain lines
 

Owner: Department of Defense, Hurlburt AFB
Project Location: Building 90074, Hurlburt AFB, Florida
Prime Contractor: SheltonDean, Inc.
Contract: # FA-4417-07-M-K003
Contract Value: $62,642
Percentage of Self-Performed Work: 100%

Self-Performed Work: All supervision and management, electrical and mechanical.

Description of Contract: Install HVAC in computer rooms
 

Owner: Department of Defense, Key West Naval Air Station
Project Location: Key West Naval Air Station, Florida
Prime Contractor: SheltonDean, Inc.
Contract: #N62467-06-C-2796
Contract Value: $90,000

Self-Performed Work:
All project management, on-site supervision, and project administration. Project management included equipment selection, approval, and scheduling. Project administration included the use of the Navy's Prime Contract online project management software.

Description of Contract:
Furnish and install 12 complete HVAC systems for tental units. Installation of compressor units was done so on a hurrican stand to prevent future water damage (previous water damage created the need for replacement). New air handlers were tied into existing ductwork system. All units were replaced in coordination with the occupants.

Owner: Department of Defense, Seymour Johnson Air Force Base
Project Location: Seymour Johnson Air Force Base, North Carolina
Prime Contractor: SheltonDean, Inc.
Contract: #FA4809-06-C-C003
Contract Value: $763,599

Self-Performed Work:
On site project managment and trade supervision, quality control and safety plan implementation and execution, material handling and storage, daily cleanup and housekeeping, daily quality control inspections, daily and weekly safety and progress tracking, and all aspects of project administration.

Description of Contract:
Retrofit five existing pre-engineered metal building roofs with new metal roof panel system. Remove and replace four low-slope BUR roof systems. All sheet metal, gutters, and downspouts were included. Work was performed on flight line hangars and with no interruptions to daily operations.
 

Owner: Department of Defense, Seymour Johnson Air Force Base
Project Location: Seymour Johnson Air Force Base, North Carolina
Prime Contractor: SheltonDean, Inc.
Contract: #FA4809-06-C-C002
Contract Value: $331,250

Self-Performed Work:
On site project management and trade supervision, quality control and safety plan implementation and execution, material handling and storage, daily cleanup and housekeeping, daily quality control inspections, daily and weekly safety and progress tracking, and all aspects of project administration.

Description of Contract:
Removal of a BUR roofing system down to the steel deck and replacement with a BUR roofing system applied in hot asphalt. Additional scope included removal of obsolete mechanical items and associated deck replacement as well as refurbishment of mechanical equipment surfaces.

Owner: Department of Justice, Federal Bureau of Prisons
Project Location: FCI Miami, Florida
Prime Contractor: SheltonDean, Inc.
Contract: #DJB30903-023 & #DJB30903-024
Contract Value: $4,350,000
Percentage of Self-Performed Work: 100%

Self-Performed Work: All supervision and management, roofing, and labor.

Description of Contract: Provide emergency temporary roof repairs on approximately 300,000 SF of damaged roof area after Hurricane Wilma. After temporary roof repairs were completed, we began the installation of approximately 100,000 SF of low-sloped roofing systems and the installation of 200,000 SF of hurricane resistant standing seam metal roofing and metal retro-fit systems.
 

Owner: Department of Justice, Federal Bureau of Prisons
Location: Federal Correctional Institution Tallahassee
Prime Contractor: SheltonDean, Inc.
Contract: #DJB31402-028
Contract Value: $29,950
Percentage of Self-Performed Work: 100%

Self-Performed Work: All supervision, management, and roofing.

Description of Contract: This project consisted of re-roofing three staff housing units located at FCI Tallahassee. Removal of the existing asphalt shingle roofing system was required prior to the installation of new 50 year fiberglass architectural roofing system. Severe roof slopes of over 14 and 12 resulted in a higher difficulty level for this small project. In addition to the steep slope roofing, one of the units had multiple roof levels that were replaced with low-slope PVC roofing membrane.
 

Owner: Department of Justice, Federal Bureau of Prisons
Location: Metropolitan Detention Center Guaynabo Puerto Rico
Prime Contractor: SheltonDean, Inc.
Contract: #DJB30605-053
Contract Value: $2,300,000
Percentage of Self-Performed Work: 100%

Self-Performed Work: All supervision, management, and roofing.

 

Owner: Department of Justice, Federal Bureau of Prisons
Location: United States Federal Penitentiary, Atlanta, Georgia
Prime Contractor: SheltonDean, Inc.
Contract: #DJB30103-052, -053, -054, -055
Contract Value: $3,340,000
Percentage of Self-Performed Work: 35%


Self-Performed Work: All supervision and management, fencing, masonry, carpentry and specialties.

Description of Contract: This series of design/build projects resulted in a complete upgrade to the perimeter security systems for USP Atlanta. Separate phases of work had to be scheduled to maintain the high security levels of the institution while maintaining access to this fully operational institution. The scope of work for these projects breaks down as follows:
Phase I – Installation of a complete perimeter fence, including the installation of an “up-and-over” for the 55’ administration building.
Phase II – Installation of microphone and microwave motion detection to protect the perimeter.
Phase III – Construction of perimeter roadways to separate the security traffic from the operational traffic around the entire institution.
Phase IV – Installation of entire series of pan/tilt/zoom cameras and integration of these cameras and the related motion detection systems along with the upgrade of the existing control room, including a switch-over that was made in less than 48 hours.
 

Owner: Department of Justice, Federal Bureau of Prisons
Project Location: United States Federal Penitentiary, Atlanta, Georgia
Prime Contractor: SheltonDean, Inc.
Contract: #DJB30103-154
Contract Value: $2,298,449
Percentage of Self-Performed Work: 35%

Self-Performed Work: All supervision and management, concrete, masonry, carpentry and specialties.

Description of Contract: Provide for the complete construction of a multi-purpose maintenance facility. This included site development, construction of the facility and integration of the facility into the Institution’s security systems. Location and function of the building required the installation of several specialty items including detention grade hardware, vehicle lifts and welding stations. Also, the installation of a perimeter roadway was coordinated with construction so that access to the project was maintained for the entirety of the project.
 

Owner: Department of Justice, Federal Bureau of Prisons
Project Location: Metropolitan Detention Center, Guanynabo, Puerto Rico
Prime Contractor: SheltonDean, Inc.
Contract: #RFP-GUA-0020
Contract Value: $2,495,865
Percentage of Self-Performed Work: 100%

Self-Performed Work: All management and supervision, mechanical, plumbing and electrical.

Description of Contract: Chiller Replacement
 

Owner: Department of Justice, Federal Bureau of Prisons
Project Location: Federal Correctional Institution, Jesup, Georgia
Prime Contractor: SheltonDean, Inc.
Contract: #DJB30703-018
Contract Value: $588,732
Percentage of Self-Performed Work: 100%

Self-Performed Work: All management and supervision, mechanical, electrical, and plumbing.

Description of Contract: Installed a temporary chiller while we teamed with design professionals to assess the chiller failure and collect data on the existing design. A 500 ton chiller was procured along with pumps and cooling towers. During this time, the design team issued a complete design for the new installation of the chiller along with a new piping layout. Using the design/build process, the project installation was successfully completed in five weeks.
 

Owner: Department of Justice, Federal Bureau of Prisons
Location: United States Federal Penitentiary, Atlanta, Georgia
Prime Contractor: SheltonDean, Inc.
Contract: #DJBATLFPZ6006
Type of Contract: Boiler Repair
Contract Value: $79,000

Percentage of Self-Performed Work: 95%

Self-Performed Work: All supervision, management, and mechanical.

Owner: Department of Justice, Federal Bureau of Prisons
Project Location: United States Penitentiary, Atlanta, Georgia
Prime Contractor: SheltonDean, Inc.
Contract: # DJB30103-060
Contract Value: $108,354
Percentage of Self-Performed Work: 100%

Self-Performed Work: All supervision and management, electrical and mechanical.

Description of Contract: Repair boiler
 

Owner: Department of Justice, Federal Bureau of Prisons
Project Location: Federal Correction Institution, Marianna, Florida
Prime Contractor: SheltonDean, Inc.
Contract: #DJBMNAFPZ10002
Contract Value: $52,000
Percentage of Self-Performed Work: 100%

Self-Performed Work: All supervision, management, and mechanical.

Description of Contract: Installation of Backflow Preventer
 

Owner: Department of Justice, Federal Bureau of Prisons
Location: Metropolitan Detention Center Guaynabo Puerto Rico
Prime Contractor: SheltonDean, Inc.
Contract: #DJB30605-054
Contract Value: $1,700,000
Percentage of Self-Performed Work: 100%

Self-Performed Work: All supervision and management, and mechanical.

Description of Contract: Design/build six custom air handler units for corrosive environment.
 

Owner: Environmental Protection Agency
Project Location: Montgomery, Alabama
Prime Contractor: SheltonDean, Inc.
Contract: EP-C-07-002
Contract Value: $2,145,500
Percentage of Self-Performed Work: 85%

Self-Performed Work: All supervision and management, electrical and mechanical.

Description of Contract: Construction of central chiller plant
 

Owner: NAS Meridian
Project Location: Building 106, Meridian, Mississippi
Prime Contractor: SheltonDean, Inc.
Contract: #N69450-07-M-5330
Contract Value: $70,962
Percentage of Self-Performed Work: 90%

Self-Performed Work: All management and supervision, and electrical.

Description of Contract: Electrical work, replace floor tile, replace door and repainting of two rooms.
 

Owner: Veterans Administration
Project Location: Bay Pines Hospital, St. Petersburg, FL
Prime Contractor: SheltonDean, Inc.
Contract: #VA516-C-0014, -0015, -0016, -0017, -0018
Contract Value: $1,680,000
Percentage of Self-Performed Work: 35%

Self-Performed Work: All project management, on-site supervision, and project administration. Project management included equipment selection, approval, and scheduling.

Description of Contract: Renovations-Patient Lav Counters, Public Restrooms, Nourishment Centers, Security System.